pump

hi ya all, after fixing my stator issue I got the bike running and i put the original cans on for the m.o.t and it ran like a bag of ****! stalled everywhere! at first i thought it was the standard can as it is set up for the mivv's but when i changed them back it still did it. I then thought...

I have a 2017 Tuono which has developed a small leak on the bottom bolt of the water pump casing. It looks like oil, not coolant, which I suppose is feasible as the water pump will be driven from a spline in the engine so there must be a seal involved. Anyone had anything similar or any other...

Hello again. I have just taken my 1st Gen Mille for a shakedown run. I have just drained the oil and cleaned the engine as I suspected the bike had been overfilled prior to my delivery of it in March. After refilling and checking the levels I took it for a run and then after a night left alone...

Hi guys Wondering if anyone has a fuel pump for sale for a gen 1 mille. My low fuel sensor has gone and seeing as I cant seem to buy one anywhere , I shall have to get another fuel pump. Does anyone know if the gen 2 fuel pump works as well and is that just a straight swap. Cheers for any...

My fuel pump isn't always primeing seems to be a lot worse in the morning sometimes it only primes for half the time it's ment to any ideas I quess it wats causing me to cut out too

Hey folks, My 04 RSV Tuono blew out its high pressure fuel line recently and I replaced it with the OEM part, and did the fuel filter and line to the outside with the parts from AF1 Racing. Since I've done that, it's taken to backfiring loudly on a slight bit of throttle opening. In...

Hi guys, my 05 factory still refuses to turn over on the button. I was wondering whether if the fuel pump was at fault, would the ECU prevent current getting to the starter & ignition circuits. All wiring and switches all got a clean bill of health & were bypassed temporarily. Dash shows fault...

Hi everyone, I am new to forum and any advice on my much loved 2002 RSV mille 1000 r would be greatley appreciated.. The problem raised itself when I was approx 3 miles into a ride it started missing and stopped. I raised the tank and tried the starter and it started revved then ran lumpy then...

My bike recently let go around the fuel pump/tank seal. Resin tank. Have got a new O ring but not sure weather to use a sealant as well or just dry fit. I tried to re-use the old one with some of that blue 'non setting fuel resistant' crap before & it was a disaster. Any advice welcome:dunno

went out for a spirited scratch along A and B roads with my mate, hes an ex club level racer on a ducati 1198s ive got a gen 1 tuono, so had to push to keep up on times was out for about 4 hours in total with breaks for fuel and coffee the last half hour I had forearm pump so much so I had...

Hello all, Can anyone offer advice please? Following a leak on the right hand casing of the bike and trawling through these forums i have come to the conclusion that my water pump seal has gone. I have taken my bike to a local mobile mechanic who ordered the new seals then decided he couldn't...

Hi there, After doing my pre mot checks today I've found that the fuel pump had a leak at the rear of the pump. Having now removed pump and searching online for a new seal I've found that 'ApriliaPartsOnline' have two different seals listed for a '02 RSV Part Number : AP8144477 (£12.01) and...

Hi Guys Does anyone have a spare relay I can buy. My bike cut out the other day while riding. Rolled it home and on inspection I noticed there was no fuel getting to the plugs. When the key is turned I cannot hear the fuel pump priming either and therefore believe this is the problem. going...

Hi all, Hate to start my first post on this forum with a problem but I’m hoping that you guys can point me in the right direction…. I took the datatool System 3 alarm off recently (thank F*ck for that!) on my 2003 Gen1 Mille and when I went to start for the first time, the fuel pump didn’t...

Dear all, I had a slight water leak from the water pump weep hole and was preparing myself for forking out the 300 odd quid to have it fixed. However I thought I'd try a flush out and coolant change first first. I got some Halfords Advanced OAT coolant and a bottle of Holts rad flush, dumped...

Hi all, i've been a broswer on this forum since i got my RSVR in 2012 and up until now i've been lucky enough to have a faultless bike...... until now and i respectfully ask for help. After a winter in the garage the battery died. (even though it was on optimate) I fitted a new battery and...

I hate my first post to be a problem, but yeah, it is. She shut down during the first run after I replaced a bad fuel pump..mid throttle, about 6k rpm 3rd gear. Ran excellent right til it shut down, about 15 miles into the ride. And now wont start. Battery voltage is 13, bike cranks healthy...

Alright guys I need some help! I just got my new fuel pump in the mail yesterday and it's time to swap it out! Also we have a company bike ride tomorrow and the bikes not going to be up and running til i get done swappin her out! My question to you all is do i have to completely empty the fuel...

I've almost finished rebuilding my bike since being knocked off, just have to fit a new tank rather than get the original resprayed. So a quick question to pre empt any problems. I've sourced a tank complete with the fuel pump still fitted. When I take the old tank off, will the new pump need...

Hi how would I know if mines leaking , Aprilia rsv 1000 ? bike runs fine ( had been standing for a few months sprag clutch had gone ) but noticed the coolant cap had a milky solution round it , spark plugs are fine so I dont think its head gasket Thanks eddie