issues

Hi everyone I'm new here, and am glad to be here. First I would like to say I am a proud new owner of a 2000 RSV Millie. I haven't had a chance to ride her yet because of the issue I am having. My issue is that the back or will not turn over. You can hear the starter and the solenoid engaging...

I am having some starting issues with my bike. Every now and again, i try to start my bike but when i press the starter the all the clocks reset, you get a clicking from somewhere deep in the bike, the rev counted does a mad dance and it will turn the engine like its got a duff battery. The...

Hello All, have a issue and looking for any solutions/suggestion? 1. My 2007 Tuono stopped running while pulling into a gas station. Totally dead checked the obvious, towed it home 2. Replaced the Shorai battery with a new standard battery, Came back to life but its only charging at 12.5 to...

Hello. About one month ago, i got myself an RSV. It runs fine and i am happy about, but i have a couple concerns. I have ridden the bike over 2000 km since i got it. The first thing that i want to ask about is "EFI" light in the display. It has started showing two times, but it have just...

Hello all, Recently tried to install a Dr Rossi ECU into my 2002 RSV and it won't take. For some reason the bike goes into some form of a "limp mode" very slow acceleration. Put the original ecu back in and off I went with no hesitation, no issues. I suppose from that analysis I am looking...

After owning my 04 factory for 3 months im having a few problems.my bike wont turn off by the key i have to use the kill switch and my power commander 3 is live all the time.this only started happening after a flat battery.and she started idiling a 3k today.help help help

Hi, I have seen many posts about the starting issues on the Gen 1 Tuono 2004 Racing and am suffering the same problems. Ive replaced my battery recently with a lithium YTX14-BS, and its kept on an optimate in a dry garage. But since I swapped the battery it seems worse than ever and just...

Hello all, I am new to the forum and new to Aprilias. I have an 04 factory that i only bought this week. The bike has an issue where it runs fine with a full tank but starts to run really rough when it gets down to about 1/4 of a tank. Any ideas I love the look of the bike but a little...

Hello all, I am new to the forum and new to Aprilias. I have an 04 factory that i only bought this week. The bike has an issue where it runs fine with a full tank but starts to run really rough when it gets down to about 1/4 of a tank. Any ideas??? I love the look of the bike but a little...

Does anyone have any bright ideas to help me get my Mille going properly again. 2 weeks ago wouldn't start, solenoid clicked but no turnover. Would start with an arc across the solenoid. I then replaced the solenoid, didn't cure the problem. Guessed that the new sol might be at fault (Cheap...

Hi All, After having bought back my old bike after 9 years .... (yeps, the same VIN), it's in need of some TLC .... She started ... not good, and the big 'Clunk' sound during the attempts, after some research determined to be the Sprag Clutch, Battery, Starter Relay Have disasambled the left...

morning all ! I've got a first gen mille owned this bike for ten years without any real issues until now !!!!! it all started with several relays falling over winter and a few wiring and switches issues which are all replaced and fixed now I have a new issue ? the bike starts and purrs like a...

Some of the mods and issues I have done/had on my Tuono Since I bought my 2013 model in March: 1 sealed Headlights modified to allow to clean inside. They dirt up really badly. The projector lenses come loose. 2 Speedo/rev counter mists up I modded this too 3 Seat on 2011, 12 and 13 are really...

Hi all I have had a few gear problems since the Tuono came out of hibernation after winter. she has only got 2500 miles on the clock and the warranty runs out in November. it seems to be a intermittent fault on the last 5 weekend rides. trying to change up the box and the lever just sticks...

Hello, Right help needed please people, as part of the pre-dyno shakedown I thought it appropriate to get the suspension, static sag etc set-up, sooooooo went to measure the max height and then settled height to work out rear sag and the shock seems way over damped, more so in rebound than...

I have a 2003 RSV 1000 R Factory Colins edition It was starting and running just fine until the battery was mistakenly connected with reverse polarity from a battery charger. Now, it will not turn over. I tried jumping the solenoid to no avail and then bought a new solenoid with no change. I...

Hi Guys, I know this issue has been discussed over and over again and I have read through countless threads, some very useful and others not so. I have a 52 plate Tuono fighter that I have had since 2003, Great bike! I have just had the slave clutch replaced everything was ok.. However went on...

Hi, had my first day out ever on my 2000 RSV Mille track bike at Snetterton yesterday. Overall I'm very happy but I have a problem with the rear. The bike has a 2001 swing arm, ohlins rear and a 520 chain conversion, this is how I bought it. I've had the suspension serviced and resprung for my...

Sorry not been on for a while but always great help on here when I do, Mille 03 went for a ride no issue, but left for a few days and went to pull clutch in when started but wasn't doing anything.lose lever Did the normal thing by bleeding system, no bubbles or any thing but still no joy with...

hi there,got a problem with a 2004 erre factory aprillia,problem is I live in Zambia and no dealers here.problems are when u turn the ignition key off bike keeps running and battery keeps going flat and found out fuel pump keeps coming on intermittently,any help appreciated many thanks gary